Alerion 33 Electric Drive - Sail Magazine

Alerion 33 Electric Drive

Author:
Updated:
Original:

Alerion’s take on electric drive utilizes the most up-to-date technology available. It involves a 7.5kw AC motor, powered by a pair of 160amp 12V DC lithium iron phosphate batteries from Mastervolt. These batteries, the first developed for the marine market, won a 2010 Freeman K. Pittman Innovation Award from SAIL. They have three times the cycle capacity of a lead-acid battery, and can be discharged by 80 percent without damage.

Lithium iron phosphate is safer than other lithium ion chemical combinations because it won’t catch fire, a recurring problem with some Li-Ion batteries—remember all the laptop battery recalls of the last few years? (To get an idea of the potential dangers of runaway batteries, check out Nigel Calder’s column in the June issue of SAIL.) The Mastervolt batteries have integral management systems designed to bring them up to charge as quickly and efficiently as possible, in conjunction with a charger that’s optimized for these batteries and can be programmed to make the most of differing shore power situations.

This system was commissioned by the boat’s owner, who sails in British Columbia, and was put together by the engineers at Alerion and Mastervolt. It was a treat to lift the engine cover and see not the usual diesel engine lurking in its cave, but a neat and tidy electric motor driving a folding propeller via a shaft and stuffing box. The batteries are installed under the cockpit seats just abaft the bulkhead, and the charger is housed between them. There’s no fuel tank, no filters to look after, no impeller to fret about, no dipstick to check, no alternator belts that need constant adjustment. Best of all, there’s no whiff of diesel fuel.

Alerion’s Scott Bryant switched on the motor (literally) and juggled the forward-neutral-reverse gear lever/throttle to ease the Alerion out of its slip, with only the faintest of hums from the motor. The silence was almost uncanny as we glided out of the marina. The throttle (rheostat?) was set up to operate just like that on a diesel-powered boat, though a volume-control knob would have worked just as well.

The motor has plenty of torque; the boat crash-stopped quickly and accelerated briskly enough to spill your coffee. There was no vibration from the motor, and at low speed, had it not been for the forward motion you’d not have known the motor was even running. There was slightly more noise at higher speeds, much of it from the water gurgling at the transom. Cruising speed is 6 to 7 knots, at which rate the batteries are expected to last for three or four hours before it’s time to plug them in for a recharge. That’s a range of, say, 24 miles, more if you’re running at low speed. When you think about the amount of time you typically have your engine running when you’re daysailing, this should be ample. There is also the potential for some power regeneration from a spinning prop when the boat is under sail, but it will take some finesse to get this working with a folding prop.

Apart from the turbulence from the prop when accelerating hard and a whine emanating from the sterngland, silence reigned supreme. And that, after all, is part of the grand appeal of sailing.

An installation like this is maybe 50 percent more expensive than a diesel engine with its associated hardware, but when you factor in the almost non-existent maintenance costs of the electric drive, it’s not at all a bad deal if you intend to keep the boat for a few years. Electric drive is still in its infancy, and as motors become more efficient and the cost of batteries comes down, so the pricing will become more competitive. In a way, early adopters like the Alerion’s owner, Vincent Argilo, are investing in the technology’s development.

But hey, never mind the money – just savor the sound of silence.

Related

FPO skys0tlm8jlrpynehcpe_NEW

A Half-century of Cruising with SAIL

I cannot say I have been reading SAIL magazine since the very beginning, but I come pretty darned close. Sometime around 1974, when I was in high school, I began buying it every month at our local newsstand and saving every issue until I had great stacks of them, as carefully ...read more

B&G-Halo20+-side-facing

Gear: B&G HALO radar

B&G’s HALO series of radars now includes the HALO20+ and the HALO20, a pair of compact radomes expressly designed for use aboard smaller sailboats. The units measure 20in in diameter and weigh a mere 11lb. The HALO20+, in particular, delivers a full 360-degree sweep every ...read more

PICTON CASTLE under sail with stunsls WV7 compressed

Picton Castle Seeks Crew

The Picton Castle is set to begin its eighth circumnavigation this spring under the command of Captain Daniel Moreland. A professional crew of 12 will guide up to 40 trainees at a time as they learn about all aspects of sailing the bark, from steering to lookout, ...read more

DSC_0013

Ask Sail: Keel Attachments

Q: I have an early ‘70s Catalina 27. The keel bolts look pretty good. My question is, why not glass over the keel to bond to the hull rather than changing the bolts if, or when the bolts are too far gone? I haven’t seen anything on this, so could you discuss? Full-keels are ...read more

04-GOPR0511

Book Review: Sailing Into Oblivion

Sailing Into Oblivion by Jerome Rand $15.99, available through Amazon As refreshing and inspiring as Jerome Rand’s 2017-18 solo-circumnavigation may have been, his account of the voyage in the book Sailing Into Oblivion: The Solo Non-Stop Voyage of the Mighty Sparrow may be even ...read more

01-1970-Dec

50 Years of SAIL

Back in early 1970, Bernie Goldhirsh and the recently founded “Institute for the Advancement of Sailing,” publisher of an annual sailboat and gear guide, launched something called SAIL. A half-century later, a look back at the magazine’s first few years provides a glimpse into a ...read more

Photo-by-Adobe-Stockpics721-2048x

Webinar: Navigating Post-Dorian Abaco

On Thursday, October 22 at 6 pm ET, Navigare Yachting presents a webinar on what to expect from Abaco post-Dorian. The event will feature the authors of The Cruising Guide to Abaco, Steve Dodge and his sons Jon and Jeff.Hurricane Dorian hit Abaco in early September of 2019 and ...read more

LunaRossaBoat2

Luna Rossa Prada Pirelli Christens “Boat 2”

Hot on the heels of the UK’s Britannia and the United States’ Patriot, Italy’s new AC75 Luna Rossa, formerly known as Boat 2, was christened in Auckland, New Zealand, this morning. As the moniker suggests, it was Team Luna Rossa Prada Pirelli’s second design. In his christening ...read more