Boat Review: Dufour 405 - Sail Magazine

Boat Review: Dufour 405

French builder Dufour Yachts added this sparkling new 40-footer to its range of Umberto-Felci-designed performance cruisers late last year.
Author:
Publish date:

French builder Dufour Yachts added this sparkling new 40-footer to its range of Umberto-Felci-designed performance cruisers late last year. It is the latest in Dufour’s Grand Large (GL) range that now comprises seven designs from 32 to 53 feet in length.

CONSTRUCTION

Dufour’s hulls and decks are reassuringly robust. Stout Twaron-reinforced stringers run the length of the hull, crisscrossed by equally strong frames that transfer rig loads down to the keel. The hull is solid, laid up by hand; the deck has a balsa core encased in injection-molded polyester, which makes it light, but very rigid.

The 405’s stem is virtually plumb and she sports a long waterline. She has a deep semi-balanced rudder that grips the water well, and the bulk of her cast iron ballast is carried in a large bulb.

UNDER SAIL

We sailed the 405 on a blustery February day. We were soon running downwind at a healthy 8-plus knots in 15 knots of cold wind. Fortunately, the light snow stopped as we turned to windward and the boat fell into a comfortable groove at an apparent wind angle of 38 to 40 degrees, and our knotmeter settled in around 8.6.

As with other designs in Dufour’s new GL range, the helm felt positive, though slightly heavy in the gusts. Most modern production cruisers need a reef at around 15-17 knots true wind speed, so I wasn’t surprised when the 405 finally lost its grip and rounded up as a prolonged 30-knot gust hit us under full sail. Bearing away on a beam reach leveled her up and wound the log up to just over 9 knots. With a single reef in each sail her good manners instantly returned and whatever we put her through after that she accepted without complaint, giving us a swift and exciting ride.

We tacked through less than 80 degrees, losing little momentum, and pointed to within 33 degrees of the apparent wind before the mainsail started to stall. Even then the 405 made a steady 7 knots. Surprisingly, when we hove-to to let the photographer back onboard, the boat stopped dead in the water with the wind around 70 degrees off the bow—a rare phenomenon on a modern sailboat.

ON DECK

The 405GL has twin wheels connected via cables directly to the quadrant above the deep spade rudder. Combined with a wide transom gate and drop-down swim platform, this allows easy access to the stern.

The helmsman has the primary winches close at hand and, thanks to the broad stern, can easily step out onto the side decks to go forward without disturbing those seated in the cockpit. All mainsail controls and halyards are led aft through clutches to self-tailing halyard winches on the coachroof. A securely fixed drop-leaf table topped with a sturdy grab handle makes moving around the cockpit quite easy.

Plentiful stowage space can be found in three cockpit lockers, two shallow and one deep, plus there is a handy liferaft locker under the aft end of the cockpit sole.

The foredeck is clear, with a recessed electric windlass and cavernous chain locker. The twin bow roller looks pretty solid and a short alloy bowsprit can be added for flying an asymmetric sail.

The fractional rig is 9/10ths with the double spreaders raked aft at a 15-degree angle. The continuous cap, intermediate and lower shrouds terminate at deck-mounted chainplates that are supported under the deck by a 1in-diameter tie rod to a large hull fillet designed to dissipate the rig loads. An inner forestay is optional.

The standard mainsail has conventional battens, an adjustable outhaul and two single-line reefing points. In-mast furling or a full-battened mainsail with lazyjacks (as on our test boat) are popular options.

ACCOMMODATIONS

dufour.int2

The 405 has a traditional "woody" interior, which is offered with either one or two aft cabins. The former has an L-shaped galley aft and a chart/coffee table between two saloon seats, with access on both sides. The latter has a linear galley and a separate nav station with a forward-facing chart table and seat. Both layouts have two heads and an ensuite forecabin.

A large fridge, accessible from the top or front, creates a sturdy surface for the cook to lean against in both layouts. Both plans are also well-equipped with good lighting and have plenty of useful stowage space. The aft head is slightly narrower than the forward one, but there still is room to shower. Both are well ventilated with ample stowage and foul weather gear.

The U-shaped settee in the saloon has washable leatherette cushions and a two-man bench seat inboard. The deep lockers and bookshelf above them are ideal for long-term cruising, and there is further stowage space under the cushions and in cave lockers behind the settees.

Although the saloon has plenty of natural light, ventilation is limited to one small port and two hatches. Headroom is a generous 6ft 5in throughout the saloon, aft cabins and heads, dropping to 6ft 2in forward.

The aft cabins are roomy, with 6ft 7in x 4ft 6in berths and generous floor space. Three opening hatches/portlights offer good ventilation, and there is plenty of stowage space in several lockers. A panel above one berth gives access to the batteries and charger, and an optional 2.5kW generator. Water and fuel tanks are underneath the berths.

Cabin sizes are identical. If you opt for only one aft cabin, you end up with a vast cockpit locker, part of which might make a small workshop.

The 405’s 40hp Volvo engine is easily accessed for servicing. We carried out several tight marina berthing and turning maneuvers to get the feel of the boat under power. She spun round in her own length and was easy to control going astern. Our boat had the optional 55hp engine and a folding 2-blade prop, which gave us power to spare and a quiet, economic cruising speed of 7.5 knots at 2,400 rpm, with a flat-out speed of 8.5 knots at 3,000 rpm.

CONCLUSION

The Dufour 405 is well organized, both above and below decks and is easy to handle under sail. A lot of thought has been put into the basic and essential elements of cruising under sail, so she rightly deserves to be popular with coastal and offshore cruisers alike.

LOA

39ft 9in

LWL

34ft 10in

Beam

13ft

Draft (board up/down)

5ft 9in/6ft 7in

Displacement

19,819 lbs

Ballast

5,150 lbs

Sail area (100% foretriangle)

881 sq ft

Auxiliary

40hp Volvo Penta diesel

Fuel/Water/Waste

52/100/12 gall

Sail area-displ. ratio

19.32 (moderate)

Displ.-length ratio

212 (moderate)

ACCOMMODATIONS

dufour.int2

The 405 has a traditional "woody" interior, which is offered with either one or two aft cabins. The former has an L-shaped galley aft and a chart/coffee table between two saloon seats, with access on both sides. The latter has a linear galley and a separate nav station with a forward-facing chart table and seat. Both layouts have two heads and an ensuite forecabin.

A large fridge, accessible from the top or front, creates a sturdy surface for the cook to lean against in both layouts. Both plans are also well-equipped with good lighting and have plenty of useful stowage space. The aft head is slightly narrower than the forward one, but there still is room to shower. Both are well ventilated with ample stowage and foul weather gear.

The U-shaped settee in the saloon has washable leatherette cushions and a two-man bench seat inboard. The deep lockers and bookshelf above them are ideal for long-term cruising, and there is further stowage space under the cushions and in cave lockers behind the settees.

Although the saloon has plenty of natural light, ventilation is limited to one small port and two hatches. Headroom is a generous 6ft 5in throughout the saloon, aft cabins and heads, dropping to 6ft 2in forward.

The aft cabins are roomy, with 6ft 7in x 4ft 6in berths and generous floor space. Three opening hatches/portlights offer good ventilation, and there is plenty of stowage space in several lockers. A panel above one berth gives access to the batteries and charger, and an optional 2.5kW generator. Water and fuel tanks are underneath the berths.

Cabin sizes are identical. If you opt for only one aft cabin, you end up with a vast cockpit locker, part of which might make a small workshop.

The 405’s 40hp Volvo engine is easily accessed for servicing. We carried out several tight marina berthing and turning maneuvers to get the feel of the boat under power. She spun round in her own length and was easy to control going astern. Our boat had the optional 55hp engine and a folding 2-blade prop, which gave us power to spare and a quiet, economic cruising speed of 7.5 knots at 2,400 rpm, with a flat-out speed of 8.5 knots at 3,000 rpm.

CONCLUSION

The Dufour 405 is well organized, both above and below decks and is easy to handle under sail. A lot of thought has been put into the basic and essential elements of cruising under sail, so she rightly deserves to be popular with coastal and offshore cruisers alike.

Related

01b_WALKING-KEDGE-OUT-cmykpromo

Getting More Use From Kedge Anchors

If you are cruising, you need at least two anchors on board for the simple reason that you must have a backup. Imagine having to slip your anchor on a stormy night with other boats dragging down on yours, or having your rope rode severed by some unseen underwater obstacle, ...read more

SailAwayCharter

How-to: Navigating on a Bareboat Charter

So you graduated from navigation class where you practiced dead reckoning, doubling the angle on the bow and maybe even celestial nav, and you now feel well prepared for your first charter trip. Well, you won’t be doing any of that on vacation—not past the first day, anyway.Most ...read more

04-Turtle-rescue

Turtle Rescue in the Vic-Maui

Strange and often wonderful things can happen in the course of an offshore sailboat race, and one of the strangest and most wonderful things we’ve heard of recently took place during the 2,300-mile 2018 Vic-Maui race, from Victoria, British Columbia, to Lahaina, Hawaii.It ...read more

dorcap-open-blue

ATN Inc: Dorcap

COOL SLEEPYou’re fast asleep in a snug anchorage, forehatch open to catch the breeze, when you’re rudely awakened by a sneaky rain squall. Now you’re not only awake and wet, you’re sweltering with the hatch closed. Sucks, right? That’s why ATN came up with the Dorcap, an ...read more

HIGH-RES-29312-Tahiti-GSP

Ask Sail: Who has the right-of-way

WHO HAS RIGHT-OF-WAY?Q: I sail in Narragansett Bay, which is a relatively narrow body of water that has upwind boats generally going south and downwind boats generally going north. When sailboats are racing, the starboard tack boat has the right-of-way over the port tack boat, so ...read more

albinheaters

Albin Pump Marine: Marine Water Heaters

IN HOT WATERSweden’s Albin Pump Marine has introduced its line of marine water heaters to the United States. Complete with 130V or 230V AC electric elements, the heaters can be plumbed into the engine cooling system. They feature ceramic-lined cylindrical tanks in 5, 8, 12 and ...read more

03-squalls4

Squall Strategies

Our first encounter with a big squall was sailing from San Diego to Ensenada, Mexico. We left at 0200 to ensure we’d get into Ensenada before our 1300 haulout time. The National Weather Service had forecast consistent 15-20 knot winds from the northwest, which was perfect for the ...read more